2025 Subaru Outback Problems and Recalls (76 Complaints)

Lane-keeping/lane-centering: The system repeatedly pulls the vehicle too far to the right. More seriously, while driving on the freeway, it has randomly and suddenly jerked the vehicle to the right with a rapid steering input. This is not simply a matter of the system being imperfect—it creates a serious safety concern because the vehicle can move abruptly toward the edge of the lane or toward an adjacent lane.

Car battery has been failing since June it will not stay charged it started out losing power over weekends now it is every day. It is so bad I purchased a portable battery charger from auto zone to jump my car.

Needed to move quickly out of way of oncoming traffic, but delay/hesitation in CVT made it almost impossible to avoid traffic.

When engine auto-restarts after Auto Start-Stop has started engine, steering wheel jerks violently if it is not completely straight, dislocated my 5th finger.

GPS goes out..dealer has tried to fix numerous times

NHTSA Complaint Narrative — Draft On July 9, 2026, in the evening, my leased 2026 Subaru Outback Touring caught fire while we were driving home. We were stopped in a left-turn lane waiting on a left-turn signal. When the light turned, the vehicle in front of us moved forward — which, in hindsight, was fortunate, because molten metal was sprayed across that exact spot moments later. The engine effectively exploded, throwing molten metal from the melted hood and engine components into the air around the car. We exited the vehicle immediately, leaving it burning in the left-turn lane. The fire department, based only about half a mile away, arrived within approximately 4 minutes, but it still took them roughly 35 minutes to fully extinguish the fire given its intensity. The vehicle had just been returned that day (or very recently) from a 3.5-week internal engine repair at the dealership. This was the third time I had reported the same underlying engine problem to Subaru — the recent lengthy repair was the first real attempt by the dealer to address it, and it failed within days of the vehicle being returned to me. My spouse and I were in the car moments before the explosion. Had we been delayed even briefly — for example, had the car ahead of us not moved forward when it did — we believe we could have been seriously injured or killed by the explosion and flying molten debris. The vehicle was a total loss. I am filing this complaint because: This was the third report of the same engine issue prior to the fire, indicating a recurring, unresolved defect rather than an isolated incident. The failure occurred immediately after a dealership repair specifically intended to fix this problem, suggesting the underlying defect was not — or could not be — properly corrected. The nature of the failure (explosive engine fire while driving, throwing molten metal across an active traffic lane) presents a serious risk of injury or death to occupants, other drivers, and bystanders

The contact owns a 2025 Subaru Outback. The contact stated that while driving during heavy rainfall, the front windshield displayed a distorted view while the windshield wipers were activated. The vehicle was taken to a local dealer, where it was diagnosed; however, the cause of the failure was not identified. The front windshield was cleaned. Upon further investigation, the contact associated the failure with the manufacturing of the windshield glass. The manufacturer was made aware of the failure. The failure mileage was approximately 2,000.

The passenger seat airbag light does NOT always come on when my wife, 93 lbs, sits in the passenger seat. It will come on with someone heavier. This also happened in the loaner car I was given, 2026 Forester, by the dealer while they investigated my car. The airbag light did not come on when my wife was in the seat. Dealer says thereshold switch is operating according to factory specification. I say the specification needs adjustment. This was NOT a problem with my 2021 WRX.

The contact owns a 2025 Subaru Outback. The contact stated that the vehicle failed to start while attempting to start it. There were no warning lights illuminated. A tow truck company successfully jump-started the vehicle, and the vehicle was towed to the local dealer. The dealer was unable to duplicate the failure. The contact returned to retrieve the vehicle, and the key fob failed to operate, and the vehicle failed to start. The dealer provided a loaner vehicle. There was no indication that the battery had failed; however, the dealer replaced the battery. The dealer had not yet determined the cause of the failure. The vehicle was not diagnosed or repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was approximately 10,000.